In the rainy season, the maintenance of agricultural machinery can not be taken lightly

At present, the country enters the rainy season, especially in some areas affected by floods. Floods and typhoons often cause heavy influx of agricultural machinery. If the agricultural machinery is not cleaned and maintained in time, the performance and service life of the machinery will be seriously jeopardized. Peasant friends must do the following aspects of repairs and maintenance work, can not be taken lightly.

When the agricultural engine is working during the daytime, the fuel tank generates negative pressure in the fuel tank as the fuel is consumed. The hot and humid air enters the fuel tank from the fuel tank cap; when the vehicle is stopped at night, the temperature drops rapidly, and the hot air entering the fuel tank is cooled accordingly, and the water vapor is easy to be cooled. Saturated, when it encounters a colder tank wall, it adheres to the tank wall to congeal the water droplets. In this way, the day and night alternately reciprocate, and the moisture in the tank increases. After the rainwater enters the cylinder through the exhaust valve, a small amount enters the oil sump through the gap between the piston ring and the inner wall of the cylinder tube, and most of it remains in the cylinder. When the piston goes up, the water is incompressible, showing a lot of resistance, similar to the phenomenon of burning tile, holding shaft, but also similar to the lack of battery power, starting motor powerless. The essence is that the resistance of water impedes the movement of the piston rod assembly. Once the water is removed, the fault is solved.

In addition, when the engine oil contains excessive water, the performance of the engine oil will decline. Excessive moisture will reduce or even invalidate the use of some additives in the engine oil under certain conditions, which will damage the viscosity of the engine oil and prevent the oil from being able to A good lubricant film is formed by the movement and the friction, so that the machinery generates abnormal wear and even causes mechanical failure. In general, when the engine oil contains excessive water, the engine oil will be emulsified, showing a milky white foam state. In this case, to avoid damage to the engine, we need to clean the engine and change the engine oil. In order to avoid or reduce the accumulation of water in the tank, in the season when the air humidity is high and the temperature difference between day and night is large, the fuel in the fuel tank should be filled up at night, and the wet air does not come into contact with the tank wall, and it is naturally difficult to form water droplets. In addition, the maintenance should be strengthened, and the accumulated water in the sedimentation cup in the filter should be promptly dumped to remove the rust stains and the like in the fuel tank and the filter.

After the motor has been exposed to moisture, the heat dissipation performance of the agricultural motor is reduced, causing damage to the insulation and causing a short circuit to burn out the motor. An incandescent lamp can be used to bake water and evaporate, and it can also air dry in a ventilated place. However, it should not be heated by current or baked by fire to prevent short circuits or damage to the insulation. After drying, it is necessary to use a multimeter to check the insulation properties of each winding coil. If it is found to have poor insulation, it should be overhauled.

All kinds of commonly-used agricultural implements should be first cleaned of mud and dirt in their appearance and inside the machine, and then they should be rust-removed, lubricated, repaired, and kept for their respective technologies, and the surface of unpainted paint should be rubbed with rust-proof oil. Each bearing, screw, etc., must be re-filled with lubricant. In order to prevent wood and cotton products from decaying, rainwater intrusion should be strictly prevented. It is best to remove it, wash it and dry it, and store it in a dry place. Before heavy rain, check the wear condition of the tractor tire pattern. If the wear condition is serious, replace the new tire in time to prevent the skidding in the rainy day and affect the safe exercise.

PRODUCT  SPECIFICATION NORMAL PACKING
Cimitidine Tab. 0.2g 0.4g
Injection 200mg/2ml
1000`S/Tin
100`S/Box
Hyoscine Butylbromide Inj 20mg/Ml 10'sx10tray/Box
Lansoprazole Capsule 30mg 2x12/Blister/Box
Metoclopramide Injection 10mg/Ml 100amps/Box
Omeprazole Tablet 20mg
For Injection 40mg
2x12's/Blister/Box
10Vials/Box
Pantoprazole Capsule, Tablet 40mg 2x10`s/Box
Amlodipine Besylate Tablet 5mg ; 10mg  
Atorvastatin Tablet 10mg, 20mg 10x10`s/Box
Fursemide Inj.  20mg/2ml 10'sx10tray/Bo
Irbesartan Tablet 150mg 10 x 10`s/Box
Lovastatin Tablet 40mg 12'sx1blister/Box
Nitroglycerine Aerosol  14g 200dose 1vial/Box
Simvastatin Film-coate Tab. 10mg; 20mg 10x10`s/Box
Tirofiban Injection 12.5mg/50ml 1`s/Box
Valsantan Tablet 80mg 10x10`s/Box

Respiratory & Digestive System Drug

Ambroxol Injection,Cimetidine Injection,Xylometazoline Nasal Spray,Hyoscine Butylbromide Injection

NINGBO VOICE BIOCHEMIC CO. LTD , https://www.pharma-voice.com